Support road.cc

Like this site? Help us to make it better.

New cassette: 11-32 to 11-25......Di2 now not shifting correctly. Any ideas?

My bike's stock componentry was Ultegra Di2 6800 (compact 11-32 / 50-34)

Last month installed new semi-compact R8000. Chain left as was. Smooth shifting as per usual.  Very happy. All good.

Two days ago, I ditch the Ultegra cassette/chain and add a shiny new Dura Ace C9000 11-25 cassette and a KMC X11EL (nothing out of the ordinary) - but ever since, the shifting is all out...ESPECIALLY from 11 to 10

It actually shifts kind of OK between 9 - 1 but no where near as crisp as it was before. No amount of micro shifting does the trick. Basically, if you get it perfect in one area (near enough impossible) it goes out in another.

For the KMC chain, I have kept the same chain length again - though it was slightly shorter due to old one having 1cm stretch - and visually it looks OK....but I can't be 100%

Also, mech hanger looks OK and is unlikely to have been damaged during work being carried out....but again can't be 100%

So, I'm confused: too long a rear mech cage... chain compatibility/length... alignment issues...bent hanger or bent cage.....or what?!

Any ideas?

Thanks

If you're new please join in and if you have questions pop them below and the forum regulars will answer as best we can.

Add new comment

31 comments

Avatar
andsaw | 5 years ago
0 likes

Try putting chain over big front ring and big ring on cassette and miss out the rear derailleur altogether and add one full link will be correct length of chain.

Avatar
CXR94Di2 | 5 years ago
0 likes

Its an odd one, but long cage derailleurs shouldnt spoil the shifting.  chain length and setup are the usual culprits

The obvious clue, taking your comment, is that when you change the cass back to the ultegra 11-32 all works fine again.  So the issue points to the DuraAce cassette.  Do you have another 11-25 cass either ultegra or sram to try? 

Avatar
mc | 5 years ago
0 likes

Looking at the photos, the B-screw needs adjusted to bring the top jockey wheel nearer the cassette while on the biggest sprocket, however that may mean it fouls on the smaller sprockets.

The problem may be the GS is designed to have a higher ramp over the cassette, so with the B-screw adjusted so it clears the small sprockets, the gap is too large on the big sprockets, which can cause imprecise changes/jumping.
Whereas the SS will be designed to have a shallower ramp, and keep closer to the sprockets. (Ignoring the chain growth problem, if you were to fit it to a wide range cassette and adjust it to clear the large sprocket, it would likely be too far away on the small sprockets, giving shifting problems on the smaller sprockets)

Avatar
rambino replied to mc | 5 years ago
0 likes

mc wrote:

Looking at the photos, the B-screw needs adjusted to bring the top jockey wheel nearer the cassette while on the biggest sprocket, however that may mean it fouls on the smaller sprockets.

The b-screw is currently all the way out - so don't think I can get it any nearer the cassette. Besides, it doesn't seem to make a huge amount of difference how the b-screw is set.

 

kevvjj wrote:

That chain looks too short by a couple of links at least. That shouldn't really affect the shifting as much as you state though. Have you played around with the limit screws?

 

Are you absolutely sure about chain length? Look at how stretched it is in the big-big picture. I'd be worried taking any more off.

And no, I haven't fiddled with the limit screws. If memory serves me correct you need to be extra careful with the limit screws on Di2 RD's? Apparently if not set correctly it can greatly reduce battery life? I'll have a go anyway.

 

Thanks

Avatar
kevvjj replied to rambino | 5 years ago
0 likes

rambino wrote:

mc wrote:

Looking at the photos, the B-screw needs adjusted to bring the top jockey wheel nearer the cassette while on the biggest sprocket, however that may mean it fouls on the smaller sprockets.

The b-screw is currently all the way out - so don't think I can get it any nearer the cassette. Besides, it doesn't seem to make a huge amount of difference how the b-screw is set.

 

kevvjj wrote:

That chain looks too short by a couple of links at least. That shouldn't really affect the shifting as much as you state though. Have you played around with the limit screws?

 

Are you absolutely sure about chain length? Look at how stretched it is in the big-big picture. I'd be worried taking any more off.

And no, I haven't fiddled with the limit screws. If memory serves me correct you need to be extra careful with the limit screws on Di2 RD's? Apparently if not set correctly it can greatly reduce battery life? I'll have a go anyway.

 

Thanks

I think you misread my quote. Indeed I believe the chain needs lengthening - it is currently too short.

Avatar
kevvjj | 5 years ago
0 likes

Oh, and if your new chain shifts perfectly on your old cassette then I would also check (as previously advised) the cog orientations on the new cassette.

Avatar
kevvjj | 5 years ago
0 likes

That chain looks too short by a couple of links at least. That shouldn't really affect the shifting as much as you state though. Have you played around with the limit screws? From experience I have found that there is often a subtle difference in overall width between some cassettes and getting the limit screws adjusted makes some difference, especially when shifitng from the biggest cog.

I really would also check the B screw adjustment too.

Avatar
Podc | 5 years ago
0 likes

Sorry if this is insulting but is the wheel seated in the drop-outs properly?

Avatar
rambino replied to Podc | 5 years ago
0 likes

Podc wrote:

Sorry if this is insulting but is the wheel seated in the drop-outs properly?

No, not insulting...

Just a moment ago I removed the wheel, checked the cassette and inspected the dropouts and all looks good.

Everything should work together fine - compatibility should not be an issue.

Current and last generation Dura Ace and Ultegra are cross compatible. And the 11spd KMC chain has been specifically designed with these groupsets in mind. It should work!

I'm almost back to thinking the mech hanger is slightly bent, but ...the drivetrain returns to normal if I go back to the ultegra cassette, so it's unlikely.

I'd temporarily go back to the 11-32 had I not shortened the chain so damn much!

I'm totally at a loss. 

Looking like a LBS trip.

 

 

 

Avatar
rambino | 5 years ago
0 likes

Yes, I did the cassette myself. 

Chain definitely 11 spd

Really can't see why KMC would make a chain that wasn't compatible with Shimano 11spd drivechains. I've checked online and can't find any mention of compatiblity issues.

I bought the cassette, 2 new Corsa G+ clinchers, lates tubes and the KMC X11el chain to breathe new life into my bike's recently redundant stock DT Swiss RR21 wheels, which had been shod with GP4000 clinchers. The sidewalls had worn through on the Contis so I'd been cycling around on the massively practical Bora 50 tubulars. But get this, after fitting the new tyres, tubes, chain and cassette, I took the bike for a ten minute spin to a mini Sainbury's. And in that time, all of ten minutes, I somehow managed to destroy both brand new tyres. First the front brake shoe spun around, destroying the tyre wall and buckling the wheel, then, when i got home to inspect the damage, I realised that my rear tyre had a massive gash in it, just above the side wall. Talk about bad luck, right? That or somebody sabotaged my bike whilst I was in Sainsbury's. Both tyres now complete write-offs. Anyway, this is why I've gone back to the really annoying Bora tubulars which you see in the photos. Though, weirdly...the 11-25 shifts slightly better attatched the Campy free hub body than the DT Swiss. Very odd, very confusing and very annoying. I can still ride my bike but the shifts are just very clunky. Forget about shifting out of the saddle whilst attacking a climb! Because hey, that's always been my strong suite!! Not...

Now I'm waffling...

Thanks for the help and advice

Avatar
CXR94Di2 | 5 years ago
0 likes

The final photo, there looks to be plenty of wrap around the 11t cog and the jockey wheel.

A quick check, you fitted a 11 speed chain not a 10speed? There is a small difference in external width, a chain can sometimes be reluctant to drop down a cog because it's sits on the edge of the larger cog.

Did you fit the Cass yourself? Check the cogs are all facing the correct way, eg all numbers face outward

finally it could be just a compatible issue and kmc doesn't like the Dura ace cassette

Avatar
rambino | 5 years ago
0 likes

Here you go...

Avatar
CXR94Di2 | 5 years ago
0 likes

the small small photo, the chain looks slack as though the derailleur has no more spring tension. Take one more photo with it big chainring and 11t cog please. I would say chain is too short by one link(2pairs)

Avatar
rambino | 5 years ago
0 likes

Small-Small

Avatar
rambino | 5 years ago
0 likes

Can't upload 2 at the same time for some reason, but here goes....

Looking at the bib-big picture I'd say it almost looks like I've already taken out 1 too many links, right? Though, it's not as if I'm ever going to be riding in this gear so perhaps it's fine as is?

 

Avatar
madcarew | 5 years ago
0 likes

Better diagnostic photos are big-big and small - small.

Avatar
CXR94Di2 | 5 years ago
1 like

Before you start removing links from chains, take two side on photos of the bike showing the chain ring and derailleur in the whole photo.  One photo with the chain on the inner ring and on 11t cog and the other photo with the chain on the outer ring on the 11t cog.

just by looking at the derailleur positon, it should be clear whether you need to remove or even get a longer chain, see my derailleur in big chain ring and 11 cog

 

Avatar
rambino | 5 years ago
0 likes

Thanks guys.

Tonight I tried out my old Ultegra 11-32 - just to be sure about there being no hanger/cage damage - and the shifting was buttery smooth between all shifts.

So, I guess that means it must be to do with the chain length and b-screw then

I'll have a fiddle around tomorrow and if I cant sort it out myself then it'll have to be a LBS job.

Oh and just one more thing... if I accidentally remove too many links on the chain, will it be OK to reinstall one of the links with the regular pin or would I need to use another quick link?

Avatar
madcarew replied to rambino | 5 years ago
0 likes

rambino wrote:

Thanks guys.

Tonight I tried out my old Ultegra 11-32 - just to be sure about there being no hanger/cage damage - and the shifting was buttery smooth between all shifts.

So, I guess that means it must be to do with the chain length and b-screw then

I'll have a fiddle around tomorrow and if I cant sort it out myself then it'll have to be a LBS job.

Oh and just one more thing... if I accidentally remove too many links on the chain, will it be OK to reinstall one of the links with the regular pin or would I need to use another quick link?

If it is a shimano chain you will need to use a specific shimano replacement pin, but really it's easier to just use one or more quick links.

Avatar
madcarew | 5 years ago
0 likes

Your mech is no issue as it is designed to shift on any sprocket down to a 10. The shimano recommendation is that if going above a 28 for largest sprocket you will need a gs derailleur. The issue is simply chain length. You have about 6 extra links in it. Fix this and the B screw and you will be fine.

Avatar
Jimthebikeguy.com | 5 years ago
0 likes

As above, your chain is too long,so is your mech,and your b screw is way out. Fix all 3.

Avatar
VeloUSA | 5 years ago
0 likes

Two issues you are faced with.

1. If you're running a GS cage, Shimano states low sprocket minimum is 28t. Yeah, didling aound with the b-screw might get it to work but the spring tension will be off causing the 10-11 shift issues to occur. Ideally an SS cage for 11-25 is the better match.

2. Shorten your chain. Here's an how to video..skip to 3:34 for mathmatical formula.

https://www.youtube.com/watch?v=Vg2SoOOrpE8

Avatar
fukawitribe | 5 years ago
0 likes

Anecdotal evidence from the 'tubes suggest that GS derailleurs shift 25T cassettes just fine, even though not officially recommended.

Avatar
shmooster replied to fukawitribe | 5 years ago
0 likes

fukawitribe wrote:

Anecdotal evidence from the 'tubes suggest that GS derailleurs shift 25T cassettes just fine, even though not officially recommended.

Anecdotal evidence from the tubes suggests lots of things  1

It might work, so worth tweaking the B screw to bring it closer, but more likely to be sensitive to anything slightly off (chain length, bent hanger, dirty cassette or chain etc). Shimano wouldn't go to the bother of having two different derailleurs without a reason.

New derailleur not cheap, if the OP has an 11-28 lying around maybe worth a bash as a compromise?

Avatar
shmooster | 5 years ago
0 likes

If you've gone from 11-32 you must be on a GS derailleur, that has a minimum low sprocket of a 28, you're running a 25 so really need an SS derailleur. You can try tweaking the B screw but you're operating the derailleur out of spec.

https://bike.shimano.com/en-EU/product/component/ultegra-6870-di2/RD-687...

KMC chains are not directional (that I've seen anyway).

Avatar
kevvjj replied to shmooster | 5 years ago
0 likes

shmooster wrote:

If you've gone from 11-32 you must be on a GS derailleur, that has a minimum low sprocket of a 28, you're running a 25 so really need an SS derailleur. You can try tweaking the B screw but you're operating the derailleur out of spec.

Surely if it shifts perfectly well on a 11-32 it should have no issue shifting to a 25 tooth cog? Surely somewhere on the 11-32 cassette there exists a 24/26/26 tooth cog?

The issue is more than likely (as already mentioned) chain length. Given you have gone up two teeth in the small chainring and down 7 teeth in the laregest cog it would make sense that the chain lenght needs to be shorter than you had previously.

Avatar
shmooster replied to kevvjj | 5 years ago
0 likes

kevvjj wrote:

Surely if it shifts perfectly well on a 11-32 it should have no issue shifting to a 25 tooth cog? Surely somewhere on the 11-32 cassette there exists a 24/26/26 tooth cog?

By that logic you could have a 32-11 instead of an 11-32

Avatar
kevvjj replied to shmooster | 5 years ago
0 likes

shmooster wrote:

kevvjj wrote:

Surely if it shifts perfectly well on a 11-32 it should have no issue shifting to a 25 tooth cog? Surely somewhere on the 11-32 cassette there exists a 24/26/26 tooth cog?

By that logic you could have a 32-11 instead of an 11-32

If the GS derailleur shifts from 11 -12 then 25 can't be too small can it. Have a think about it...

Avatar
shmooster replied to kevvjj | 5 years ago
0 likes

kevvjj wrote:

If the GS derailleur shifts from 11 -12 then 25 can't be too small can it. Have a think about it...

 

I've thought about it, still doesn't make sense.

Avatar
Russell Orgazoid | 5 years ago
0 likes

Turn the chain around to run the other way.it may be designed to run in one direction.

Pages

Latest Comments