Support road.cc

Like this site? Help us to make it better.

Bottom Bracket Wear

I've had my pinnacle dolomite almost exactly a year now and it looks like the FSA bottom bracket is starting to go again. This will be the second time I have replaced it. I reckon I average about 90 miles per week. I rode my old Trek hybrid for about a year and a half covering the same route and didn't have any issues. Is this normal wear for this type of bottom bracket or is there a better lasting one I could install?

If you're new please join in and if you have questions pop them below and the forum regulars will answer as best we can.

Add new comment

29 comments

Avatar
ian t | 7 years ago
0 likes

Is this FSA BB the one with the internal sleeve ? Will the ultegra BB replace this ? 

Avatar
mike the bike | 9 years ago
0 likes

Although my heart belongs to Campag' and I know nothing of failure rates, hardness rating or cantilever forces, I am quite sure that the best, reasonably priced BBs I have used in over fifty years of cycling have all been Shimano. And that includes their Hollowtech II, which have never given me a second's trouble. Were I planning a round-the-world trip I would specify Shimano without hesitation.
Whilst I would admit that others, by the likes of Hope and Chris King, are quite superb, they invariably cost much, much more.

Avatar
allanj | 9 years ago
0 likes

Interesting- I've just had to replace my FSA BB rather early and was annoyed with myself for allowing water in. Maybe it's not all my fault!

Avatar
Chuck | 9 years ago
0 likes

Slight thread hijack: Anyone know if Pinnacle MTBs also ship with FSA BBs?
I've got one and was a bit surprised to discover after a few wet rides that the BB gets seriously gummed up, to the point that when I get it out again there's noticeable resistance turning the cranks. It's my first MTB with an external BB, so I assumed that's just what you get, what with all the extra crap thrown at it when riding off road- I've never noticed anything similar with my Shimano BB-equipped road bikes.
Now I'm wondering if it might have a particularly naff BB in there.

Avatar
Giles Pargiter | 9 years ago
0 likes

As far a I can remember ceramic ball bearings have a slightly higher friction coefficient and have a significantly lower rockwell hardness rating, than even case hardened steel bearings. So you can expect them to wear faster. I think I'am right to say that they are primarily designed for high temperature situations. They may be fractionally lighter ie. literally one or two grams, but basically are inappropriate on a bicycle.
As for twisting the spindle - you would have a job to do that on a mild steel one never mind carbon steel and you would'nt lose the energy anyway because it will be returned when you relieve the pressure. I know my grandfather way back in the fifties, used to delight in amusing himself by making BB's with aluminium bearing shells, with polished full hardened steel races. He made the spindles from Duralumin and made them hollow, with, again full hardened steel polished races fitted. He used them with full hardened ball bearings manufactured as accurately as possible at the time (this all happened in the late fifties- early sixties). Then he fitted them to a tandem (as well as solos). He had first calculated the stresses involved. This bore out in practice, they used to last years and years and he and my grandmother went all over the UK and many parts of Europe so equipped. The cranks were of course fastened with cotterpins then.
You used to be able to purchase square drive BB's so made although without a hollow spindle, which takes a lot more "trickery" to manufacture due to needing solid ends.

Be interesting to see what the engineers on here say; but ball bearings have the lowest friction of all contact bearings and if the radii of the races is properly calculated, even the miniscule torsional twist that occurs should be accomodated by them?

Conclusion being that modern parts manufacturers are selling us inappropriate "tat" at stupendous mark ups, that have no advantage to us as cyclists at all. If judiciously chosen a cheap (ten quid or so with spindle) square taper BB will out last all the ones mentioned so far - except the campag square taper.

Avatar
Leeroy_Silk replied to Giles Pargiter | 9 years ago
0 likes

Giles P, your Grandad sounds awesome!

Avatar
DaveE128 | 9 years ago
0 likes

In my opinion (as a design engineer), the external bottom bracket design is not a particularly good design. Bearing alignment is highly dependent on the shell being perfectly faced and the screw threads being straight, undamaged and clean. Having the bearings effectively cantilevered out from the frame on a screw thread is a bit odd when they deal with the kind of forces they experience under sprinting.

I think that low cadence is far more likely to accelerate bearing wear than high cadence - for the same power output the forces are higher for low cadence, as I expect that twisting loading on the bearings caused by flexing of the whole system (crank shaft, BB bearing holders, shell flex) will have a much more significant effect on wear than the number of cycles from a higher cadence when there is less flex due to lower forces.

Avatar
wycombewheeler | 9 years ago
0 likes

I remember having a bad experience with square taper, where the square was rounded off and an otherwise sound sealed bottom bracket needed replacing, but what was wrong with splined sealed bottom brackets? Easy to install, last for ages.

I fail to be convinced by the argument that I need a larger crankshaft diameter, it certainly doesn't add to longevity, having had to replace BB30 within a year of buying the bike. I don't think I produce so much torque that twisting of the shaft under load is costing me significant power loss.

At least the original external bottom brackets were use serviceable, simple screw in threads, unlike press fit.

Avatar
PhilJC | 9 years ago
0 likes

Totally agree with Giles. Square taper campag veloce bb in my training bike has been going for 9 years, including all year round commuting (mudguards help), and it's still really smooth ("buttery smooth" in magazine speak!).

Avatar
gmac101 | 9 years ago
0 likes

I have been to at least one lecture on reliability engineering and there were several graphs of showing time to failure - most complex items have what they call an "infant mortality" curve with most failures early in life and they then settle down to a lower level of failure. If I remember correctly bearings had a constant level of failure, i.e. the % risk of failure did not rise or fall with age. The lecturer said that the reason for this was not clear but he felt (this was in a marine engineering context ) was due to variability in the fit and installation of bearings. It surprised me that such a basic engineering component wasn't better understood. Any way Timkins who make a significant amount of the worlds bearings produce a brochure of "pretty" pictures of failure - see if you can spot yours

http://www.timken.co.uk/EN-US/products/maintdiag/Documents/5892-Timken-B...

Avatar
Rupert | 9 years ago
0 likes

Had an FSA bottom bracket with ceramic bearings and bought it thinking that it would last much longer than a bottom bracket with normal bearings.  40 How wrong I was.

 17 So I bought a new one thinking that maybe I fitted it wrong or something. Nope, new one lasted about 5 months before it started to creak and grindand changed it for a different make (rotor) that has been working for about 2 years now without any problems.

It might be that I was just unlucky and my legs are so powerful that the FSA bottom bracket couldn't cope on the other hand it might be the design of the BB and other people have been having the same problem with the FSA bottom brackets.

Then again maybe they have redesigned, after all my issues with them are now 4 years old, and I have moved on to bottom brackets I can trust.

Avatar
Judge dreadful | 9 years ago
0 likes

A lot of people I ride with, have had the metal FSA press fit BB's fail on them. I had to point out, that I feel that the use of such a BB (in particular the metal PF30), is more about keeping the cost of the bike down, than any blarney about having more flexibility in frame manufacture, if we have a frame built with a press fit friendly set up. One of my road bikes has a fairly low grade, metal FSA PF30 BB. I managed to keep it alive for a couple of years, doing up to 12000Km's a year, by keeping my cadence down, and making sure I kept it clean, and lubed properly. I think a lot of people buy a (relatively) inexpensive bike, then try to 'smash out' a cadence of ( let's say for arguments sake) 90. Then they wonder why the BB fails so early. In short, if you want to ride like a serious rider, you're going to need serious kit. Eventually my steel PF30 did fail, I replaced it with a ceramic FSA PF30, and I've been able to 'smash out' a cadence of 90, and not had the same worry about the durability. I've not had any problems with the Italian BB in my other bike thus far, which kind of adds weight to the argument, that you get what you pay for. A couple of people I ride with went down the route of adapting a steel PF30 to HollowtechII, then changing chainsets / cranks. It didn't help them much.

Avatar
Jack Osbourne snr replied to Judge dreadful | 9 years ago
0 likes
Judge dreadful wrote:

I think a lot of people buy a (relatively) inexpensive bike, then try to 'smash out' a cadence of ( let's say for arguments sake) 90. Then they wonder why the BB fails so early. In short, if you want to ride like a serious rider, you're going to need serious kit. Eventually my steel PF30 did fail, I replaced it with a ceramic FSA PF30, and I've been able to 'smash out' a cadence of 90, and not had the same worry about the durability. I've not had any problems with the Italian BB in my other bike thus far, which kind of adds weight to the argument, that you get what you pay for. A couple of people I ride with went down the route of adapting a steel PF30 to HollowtechII, then changing chainsets / cranks. It didn't help them much.

What utter tosh. Who told you that cadence would have an effect on bottom bracket longevity?

If anything, a lower cadence would have a detrimental effect... Albeit highly unlikely.

Poor seals and a lack of grease are the downfall of almost every steel bearing pf30 bottom bracket. Ceramic bearings don't corrode with the presence of water hence they work better in pf30 setups.

You are right in that they are more expensive though.

Avatar
PonteD replied to Jack Osbourne snr | 9 years ago
0 likes
Jack Osbourne snr wrote:

You are right in that they are more expensive though.

I'm serious when asking this, would you consider a ceramic worth the extra outlay? basically, if it costs 3 times the price, is it expected to last at least 3 times longer? I would consider ceramic if thats the answer to MY woes.

Avatar
Jack Osbourne snr replied to PonteD | 9 years ago
0 likes
dazwan wrote:
Jack Osbourne snr wrote:

You are right in that they are more expensive though.

I'm serious when asking this, would you consider a ceramic worth the extra outlay? basically, if it costs 3 times the price, is it expected to last at least 3 times longer? I would consider ceramic if thats the answer to MY woes.

No, I wouldn't consider them worth the extra. What I would do is look for a better enclosure for them in order to minimise the ingress of water and road slurry (which will shaft ceramic bearings).

ie. I'd look for a bottom bracket that was designed for use outside of the Atacama desert.

What is also worth doing is looking for premium steel bearings with better seals than the cheap shit FSA seem to specify. They'll almost aways need packing with grease though.

Avatar
Giles Pargiter | 9 years ago
0 likes

You just need a decent square taper BB. Should get 30,000 miles at least. So long as you grease and adjust it about every 5000 miles.

Load of expensive modern "tat" that cures a problem that didn't exist, these external BB'S.

Avatar
PonteD | 9 years ago
0 likes

I've got an FSA MegaEVO 386, doesn't fit Ultegra (its too big  2 ), so I'm stuck with this crap untiil I can afford a shimano chainset. Basically I've learnt to make sure it always gets a good lube after every wash and at the weekend after just over 1000 miles I removed the crank, pulled off the Bearing seals and gave it a good clean (as much as I could get to anyway), topped up the grease and put it all back together again, the amount of water that came out once the grease went in was worrying. This is the 2nd time I've had to do this! I agree its junk.

I have a deore HollowTech2 on my CX and that hasn't needed touching in almost 3000 miles and feels like it will do the same again before I even have to contemplate just giving it a clean out, let alone replacing.

Avatar
bikebot | 9 years ago
0 likes

Funny thread to stumble across, as I've literally just pulled the FSA bottom bracket from my bike to throw the PoS away. It started to fail (lots of creaking) after less than 2000km. A bit of web research quickly showed that I'm far from unique.

Now I have the measurements, I've ordered a Shimano replacement. They seem to be much better quality and life expectancy, and it's a cheap component. The only reason I could imagine a bike shop wouldn't use them, is to keep you coming back..

Avatar
monty dog | 9 years ago
0 likes

Depends on what model of FSA crank you have fitted - Gossamer and Energy are compatible with Hollowtech 2 but a lot of FSA models aren't e.g. Omega as they use a 19mm spindle, unique to FSA.

Avatar
jason.timothy.jones | 9 years ago
0 likes

I have FSA BB on 2 of my bikes, and I can attest that they are in fact 'pants' the issue I have with them is water getting into the bearings, on the up side, they are not to hard to strip apart and clean up

Avatar
big mick replied to jason.timothy.jones | 9 years ago
0 likes
jason.timothy.jones wrote:

I have FSA BB on 2 of my bikes, and I can attest that they are in fact 'pants' the issue I have with them is water getting into the bearings, on the up side, they are not to hard to strip apart and clean up

True but these days things are fit and forget really.The Shimano bb that fits with fsa chainset will run with no service for years.FSA need to get there act together.That said Campag gear is pretty naff also,  22

Avatar
MT63 | 9 years ago
0 likes

Thanks for the advice. Took my bike to a local bike shop and they used an Ultegra bracket. Cheaper and much longer lasting.

Avatar
Bedfordshire Clanger | 9 years ago
0 likes

Agreed. FSA bottom brackets that Evans ship with new bikes are pony. I had exactly the same problem with a Pinnacle, switched to Shimano and haven't looked back.

Avatar
MKultra | 9 years ago
0 likes

If you want something simple that lasts I would go for square taper over an external BB chain set. The wear tends to be down to externals needing to be tightened to a rather narrow torque setting, slightly too much and they eat them self in rapid order. 105's are known for it as well.

Avatar
Jack Osbourne snr replied to MKultra | 9 years ago
0 likes

The FSA mega exo bottom brackets are truly dire.

As said above, you can get an Ultegra one that will work with FSA chainsets for small amounts of pounds (if you shop around).

I think the FSA bb on my commuter lasted less than 900 miles. The Ultegra replacement has lasted over 7000 miles so far.

Avatar
KiwiMike | 9 years ago
0 likes

Recently swapped a friends FSA P.O.S for an Ultegra for about £15. Should be good for 5000k plus.

Avatar
MT63 replied to KiwiMike | 9 years ago
0 likes

I have a FSA Gossamer chainset and a FSA External bottom bracket. Looking around the internet I see quite a few people complaining about the bottom brackets wearing out quite quickly. anyone know if this would work in its place?

http://www.chainreactioncycles.com/shimano-5700-105-bottom-bracket/rp-pr...

Avatar
KiwiMike replied to MT63 | 9 years ago
0 likes
Dunluce wrote:

I have a FSA Gossamer chainset and a FSA External bottom bracket. Looking around the internet I see quite a few people complaining about the bottom brackets wearing out quite quickly. anyone know if this would work in its place?

http://www.chainreactioncycles.com/shimano-5700-105-bottom-bracket/rp-pr...

Evans Cycles tech line will tell you that you must Must MUST use the FSA tat. This is a crock. They simply want to sell you £50 worth of fast-wearing cheese instead of £15 Shimano goodness.

Clean up them threads, use Coppaslip, torque it right, take care putting the spindle through and you'll be fine.

Avatar
martb65 replied to MT63 | 9 years ago
0 likes

I had the same thing, and after lots of research I thought I would just go for it, I replaced my fsa mega exo bb with a shimano ultegra bb, and true it is a snug fit for my fsa gossamer crankset but it works just fine, no more creaking, nice and quiet and smooth running, people on here saying about their mega exo bb's not lasting long, but mine had done about 6000 miles in all weather conditions

Latest Comments